valutazioni - , GPA: ( )

Istruzioni per l'uso Garland, Modello CG-48F

Produttore : Garland
File Size : 182.97 kb
File Nome : 59e76717-11d3-51f4-45bb-c5f590f1c563.pdf

Lingua di insegnamento:

Il documento viene caricato, si prega di attendere

Scarica la tua primo

Il documento viene caricato, si prega di attendere

Scarica la tua primo

Inhalation of airborne particles of glass wool/ceramic fibers is known to the state of california to cause cancer. Operation of this product could expose you to carbon monoxide if not adjusted properly. Inhalation of carbon monoxide is known to the state of california to cause birth defects or other reproductive harm. Keep appliance area free and clear of combustibles. Part # 4520498 (01/08) Page TABLE OF CONTENTS IMPORTANT INFORMATION 2 DIMENSIONS AND SPECIFICATIONS . 4 INSTALLATION 4 Serial Plate Location. 4 General Information. 5 Legs, Casters & Leveling. 5 Clearances. 5 Gas Connections. 5 Electrical Connection. 6 Ventilation. 6 OPERATION INSTRUCTIONS . 7 Lighting Instructions. 7 Shut Down Instructions. 7 ADJUSTMENTS . 7 Pilot Adjustment. 7 Thermostat Temperature Verification. 8 MAINTENANCE & CLEANING 9 Stainless Steel. 9 Griddles. 9 Preparing A New Griddle . 9 Seasoning the Griddle 9 Cleaning Instructions (After Each Use) 9 Cleaning Instructions (For Heavy Build Up) . 9 Griddle Do’s & Don’ts 9 SERVICING 10 SAFETY 10 TROUBLE SHOOTING GUIDE . 11 DIMENSIONS AND SPECIFICATIONS INSTALLATION NOTES MINIMUM SUPPLY PRESSURE REQUIRED ELECTRICAL CHARACTERISTICS Combustible Wall Clearances Natural Propane Specifications Sides Back 7" W.C. (17.4mbar) 11" W.C. (27.4mbar) 120 V, Single Phase, 60Hz, 1 amp 6' (1829mm) power supply cord provided MANIFOLD PRESSURE REQUIRED, AFTER BUILT-IN REGULATOR 6" (152mm) 6" (152mm) 3.5” W.C. (8.75 mbar) 10” W.C. (25mbar) • IMPORTANT: Unit must be installed on legs for proper air circulation. A minimum 4” (101mm) air space must be maintained below unit for required air flow to burners. • Gas Input Ratings shown are for installations up to 2,000 feet (610mm) above sea level. BTU input ratings must be derated for high altitude installations • NOTE: No cord and plug on export units. Direct connection to junction box. VENTILATION EXPORT VOLTAGES • Commercial cooking equipment requires an adequate ventilation system. Foradditional information, refer to the National Fire Protection Association’s Standard NFPA 96. • NOTE: Export voltages are available on request. ENTRY CLEARANCE Crated Uncrated • 220-240 volt, 50 Hz, 0.4 amps, single phase. 40" (1016mm) 38" (965mm) INPUT CHART - Natural Or Propane Gas Model Number BTU/ HOUR Kw Gas Inlet Shipping Weight LBS. KGS. CG-48F 120,000 35.00 3/4" 625 284 CG-60F 150,000 44.00 3/4" 765 348 CG-72F 180,000 52.70 1" 905 411 INSTALLATION IMPORTANT: The installation must comply with local codes, or in the absence of local codes, with CAN/CSA - B149 Installation Code – latest edition or with the National Fuel Gas Code NFPA 54 ANSI Z223.1 – latest edition. All burner adjustments and settings shall be made by a qualified gas technician. Serial Plate Location All burner inputs are shown on the Serial/Rating Plate of each unit, located on the bottom of the control section near the front. When corresponding with the factory or your local authorized factory service center regarding service problems or replacement parts, be sure to refer to the particular unit by the correct model number (including the prefix and suffix letters and numbers) and the warranty serial number. The rating plate contains this information. We suggest installation, maintenance and repairs should be performed by your local authorized service agency listed in your information manual pamphlet. In the event you have any questions concerning the installation, use, care or service of the product, write or call our Product Service Department. This product must be installed by professional personnel as specified. Garland/U.S. Range products are not approved or authorized for home or residential use, but are intended for commercial applications only. Garland / U.S. Range will not provide service, warranty, maintenance or support of any kind other than for commercial applications. General Information Damage Check: check carton or crate for possible damage incurred in shipping. After carefully examining, check for “concealed” damage. Report any damage immediately to your carrier. Legs, Casters & Leveling 1. The unit must be installed on the legs or casters provided. A minimum 4 inch (101 mm) air space must be maintained below the unit for required air flow to the burner systems. Avoid placing any objects under the unit which could obstruct air flow to the burner systems. 2. For models equipped with casters,the installation shall be made with a connector that complies with the Standard for Connectors for Moveable Gas Appliances, ANSI Z21.69/CSA 6.16, Addenda Z21.69B-2006/CSA 6.16B-2006 (or latest edition), and a quick-disconnect device that complies with the Standard for Quick Disconnects for Use with Gas Fuel, ANSI Z21.41/CSA 6.9, Addenda Z21.41A- 2005/CSA 6.16A-2005 (or latest edition). 3. Adequate means must be provided to limit movement of the appliance without depending on the connector and quick disconnect device or associated piping. This can be accomplished by attaching restraining chains/cable...