Log: Refer to Section 4.3.2, “Verifying Hardware Operation” on page 4-9 for more information. Chapter 6 Storage Devices Replacement 6-33 6-34 SPARC Enterprise M4000/M5000 Servers Service Manual • December 2010 CHAPTER 7 Power Systems Replacement This chapter describes the power supply units and how to remove and replace them. This information is organized into the following topic: ¦ Section 7.1, “Power Supply Unit Replacement” on page 7-1 7.1 Power Supply Unit Replacement Power supply units are hot,
1 1 ni 1 e Caution — The latch is not an ejector. Do not bend the latch too far to the right. Doing so can damage the latch 5. Grasp the latch and pull the drive out of the drive slot. Related Information ■ “Install a Hard Drive” on page 73 ■ “Four-Drive Capable Backplane Configuration Reference” on page 77 ■ “Eight-Drive Capable Backplane Configuration Reference” on page 78 ■ “Sixteen-Drive Capable Backplane Configuration Reference” on page 79 ▼ Install a Hard Drive Installing a hard
¦ “Safety Information” on page 63 ¦ “Required Tools” on page 66 ¦ “Obtain the Chassis Serial Number” on page 66 ¦ “Obtain the Chassis Serial Number Remotely” on page 66 ¦ “Powering Off the System” on page 67 ¦ “Extending the Server to the Maintenance Position” on page 69 ¦ “Remove the Server From the Rack” on page 71 ¦ “Perform Electrostatic Discharge – Antistatic Prevention Measures” on page 73 ¦ “Remove the Top Cover” on page 73 Related Information ¦ “Managing Faults” on page 11 ¦ “Servicing C
See “Run POST in Maximum Mode” on page 28. POST error messages use the following syntax: c :s > ERROR: TEST = failing-test c:s > H/W under test = FRU c:s> Repair Instructions: Replace items in order listed by H/W under test above c: s > MSG = test-error-message c:s > END_ERROR In this syntax, c = the core number, s = the strand number. Warning and informational messages use the following syntax: 42 SPARC Enterprise T5440 Server Service Manual • July 2009 INFO or WARNING: message In COD
. Do not touch the circuitry on boards and soldered parts. Hold the metallic areas or the edge of the circuit boards. . Follow the safety instructions in the "Safety instructions" on page 31. 8.7.1 Required tools . Starting and completing the task: – key for the rack doors (if applicable) – Phillips Ph2 screw driver . Installing the expansion card: tool-less 148 Maintenance Manual RX900 S1 Expansion cards and BBU 8.7.2 Starting the task E Perform the following procedures: 1. "Opening the rack do
PIPE TEMP. THERMISTOR THE SWITCH FOR OPENING AND CLOSING OF A PANEL POWER SUPPLY CIRCUIT REMOTE CONTROL COMMUNICATION K1 DW12D1 K1-4 4 1 3 2 6 5 4 3 2 1 5 4 3 2 1 6 5 4 3 2 1 CN8 DIFFUSER CN2 RIGHT / LEFT UP / DOWN CN5 W5 TM4 C13 0.01 250V C14 0.01 250V PIPE TEMPERATURE CN3 1 2 (36) (37) 1 3 L6 BLm18
OUTDOOR UNIT Ref. No. Description Part No. AOU30CLX AOU36CLX Ord. Q'ty 1 TOP PANEL SUB ASSY 9374417032 9374417032 2 FRONT PANEL M 9374094066 9374094066 3 FAN GUARD 9374330010 9374330010 4 GRIP SIDE 9374173013 9374173013 5 SERVICE PANEL SA 9374415052 9374415052 6 RIGHT PANEL 9374095148 9374095148 7 EMBLEM-REAR 9351355005 9351355005 8 PROPELLER FAN ASSY 9366378020 9366378020 9 MOTOR,DC BRUSHLESS 9602114016 9602114016 10 CONDENSER A ASSY 9374433148 9374433148 11 VALVE COVER 9374174010 9374174010 12
. . . 4 CIRCUIT DIAGRAM..................5 INDOOR PCB CIRCUIT DIAGRAM . . . . . 6 OUTDOOR PCB CIRCUIT DIAGRAM . . . 9 ERROR CONTENTS ................ 14 DISASSEMBLY ILLUSTRATION . . . . . . . 15 PARTS LIST.......................23 STANDARD ACCESSORIES .......... 25 SPECIFICATIONS INDOOR UNIT ASU30CLX ASU36CLX OUTDOOR UNIT AOU30CLX AOU36CLX COOLING CAPACITY 30,700 BTU/hr 33,100 BTU/hr ELECTRICAL DATA POWER SOURCE 208 V / 230 V 208 V / 230 V FREQUENCY 60 Hz 60 Hz RUNNING CURRENT 15.2 A 17.7 A INPU
No. Description Part No. Ord. Q'ty ASU30CLX ASU36CLX 1 FRONT PANEL TOTAL ASSY 9315335036 9315335036 2 INTAKE GRILLE ASSY 9315336026 9315336026 4 AIR FILTER 9315014016 9315014016 5 CLAMPER(GRILLE) 9306755010 9306755010 6 RECEIVER WINDOW 9315010018 9315010018 8 CROSSFLOW FAN ASSY 9315024015 9315024015 9 BEARING C ASSY 9306628017 9306628017 10 CASING ASSY 9315331021 9315331021 22 R AND L LOUVER 9311997016 9311997016 23 SPACER B 9312441013 9312441013 26 DRAIN CAP 9367677009 9367677009 27 EVAPORATOR
Ref. No. Description Part No. Ord. Q'ty Ref. No. Description Part No. Ord. Q'ty RY-36FA RY-36UA RY-36FA RY-36UA 8 Air Filter 9359739005 9359739005 338-2 Motor Fixture-B 9359703006 9359703006 12 Base Assy 9359680000 9359680000 345-1 Filter Guide-R 9359692003 9359692003 34 Capacitor (Fan Motor) 9900270216 9900270216 345-2 Filter Guide-L 9359693000 9359693000 56 Sirocco Fan Assy 9359701002 9359701002 361 Bushing 9359733003 9359733003 63 Panel (Front) 9359734000 9359734000 379 Hinge Plate (Grille) 9
